G oog le BadWeB | Login/out | Topics | Search | Custodians | Register | Edit Profile

Buell Forum » Knowledge Vault (tech, parts, apparel, & accessories topics) » Troubleshooting (Poor Starting/Running/Handling/Ride Issues) » Idle and stalling problems « Previous Next »

Author Message
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Thursday, April 13, 2017 - 07:34 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

09 1125cr idle surges and eventually stalls runs fine off idle jumped diag wires 1 and 2 and light does not flash i have seen engine light on just before stalling any ideas
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 07:20 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

1) Clean out Iac port
2) Reset TPS

3) Intake seals leaking?
4) make sure battery conections are tight
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Saturday, April 15, 2017 - 08:01 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

This started after battery died over winter installed new battery bike ran fine before storage
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 08:14 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Reset AFV also make sure that battery is fully charged after storage.
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 08:16 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Fresh fuel
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 08:19 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Is the stator/voltage regulator good
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Saturday, April 15, 2017 - 09:43 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Put full tank of gas ran down highway for 20 minutes battery is charged voltage is 13.9 just off idle... afv?
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 11:50 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Did you do the tps reset
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 11:52 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Did you clean IAC (idle air controller port)
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Saturday, April 15, 2017 - 01:33 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Tried tps reset manually dont have a diag machine didnt make da difference as longbass im doing it right took throtle bodies off cleaned iac checked for vacuum leaks also
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 03:57 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Power switch to on then turn key to on
Take throttle all the way open wait one second let go of throttle allow to snap back to close. Do this 3 times then turn key off and back on. Crank and allow to idle for about 10 minutes to learn idle curves.[ Of course throttle snap is done with engine off but power on]
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Saturday, April 15, 2017 - 04:20 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Ordered buelltooth today gonna do a reset and remap ecm
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 04:41 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Make sure you save your original map,down load ECM droid free for non apple devices
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Saturday, April 15, 2017 - 06:54 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Clean all grounds
Top of pagePrevious messageNext messageBottom of page Link to this message

Nickbatroneygmailcom
Posted on Sunday, April 16, 2017 - 10:28 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

I saw a video on YouTube and the guy set tps to 5 it doesnt seem right but im a auto mechanic not a motorcycle mechanic
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Sunday, April 16, 2017 - 10:42 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

You dont do that with o9
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Sunday, April 16, 2017 - 10:43 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

I gave you the instructions above
Top of pagePrevious messageNext messageBottom of page Link to this message

Gabby_duck
Posted on Sunday, April 16, 2017 - 11:05 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

https://youtu.be/n2F4m2rppPA
« Previous Next »

Add Your Message Here
Post:
Bold text Italics Underline Create a hyperlink Insert a clipart image

Username: Posting Information:
This is a private posting area. Only registered users and custodians may post messages here.
Password:
Options: Post as "Anonymous" (Valid reason required. Abusers will be exposed. If unsure, ask.)
Enable HTML code in message
Automatically activate URLs in message
Action:

Topics | Last Day | Tree View | Search | User List | Help/Instructions | Rules | Program Credits Administration