G oog le BadWeB | Login/out | Topics | Search | Custodians | Register | Edit Profile


Buell Forum » XBoard » Archive through June 12, 2012 » Starter Check « Previous Next »

Author Message
Top of pagePrevious messageNext messageBottom of page Link to this message

P47b
Posted on Sunday, May 20, 2012 - 10:07 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Needing some advice on what else I need to look for.
I believe my starter on my 2003 XB9R is failing.
I have a new battery installed and it is at full charge (13.1 volts).
Starter acts like it is not getting enough power. Slow turn over or solenoid starts clicking. After the motor would get to operating temp it will start fine.
Going out to check the wire connections today.
It was doing this before I replaced the battery. The battery I had in it was 4 years old and I figured it needed a change anyway.

Before I go get a stater, if needed. What starter will fit?

I have a lead on two, a 2004 and a 2006 XB12 starters.
Top of pagePrevious messageNext messageBottom of page Link to this message

Iamarchangel
Posted on Sunday, May 20, 2012 - 10:34 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Check that you didn't replace an old and weak battery with a new one that is not strong enough.

You would get the same symptoms.

XB batteries require a stronger CCA than most other bike batteries so double-check the specs.

Slow turnover cold and okay hot tells me that it's probably not the starter that's the problem.
Top of pagePrevious messageNext messageBottom of page Link to this message

Greg_e
Posted on Sunday, May 20, 2012 - 12:55 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

I agree, sounds more like a battery issue. Try a set of jumper cables connected to a car and see if it starts cold better than normal.
Top of pagePrevious messageNext messageBottom of page Link to this message

Brother_in_buells
Posted on Sunday, May 20, 2012 - 04:23 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

clutch safety switch!?

pull the clutch when starting.
Top of pagePrevious messageNext messageBottom of page Link to this message

Biffdotorg
Posted on Monday, May 21, 2012 - 05:26 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

My XT does the same thing. It's an '08, so last fall I assumed I needed a new battery.

Once I pulled the battery and headed to Interstate for options, I had them check the battery I pulled compared to a new one. They ran a Load Test on both and my old battery checked out better than the new one.

I wish I understood batteries more, but that lead me to believe my battery was ok. My XT turns over really slow as well though.
Top of pagePrevious messageNext messageBottom of page Link to this message

Froggy
Posted on Monday, May 21, 2012 - 05:38 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Regarding the starter itself, all air cooled Buells use the same starter, it is even a common part with the Sportster too, so it isn't something hard to find new or used.
Top of pagePrevious messageNext messageBottom of page Link to this message

Skully
Posted on Monday, May 21, 2012 - 07:07 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

I have the exact same problem but my starter spins the engine easily until I ride more 15 or 20 miles in warm weather. Then, if I stop for less than 15 or 20 minutes, it acts as though the battery is dead. After that amount of time, it starts right up. Replacing the battery made no difference.
The symptoms when hot are like that of a dead battery: starter will not spin the motor and the solenoid clicks.
Top of pagePrevious messageNext messageBottom of page Link to this message

Debueller
Posted on Tuesday, May 22, 2012 - 11:32 am:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

Just installed this one:

http://www.ebay.com/itm/NEW-STARTER-MOTOR-HARLEY-D AVIDSON-SPORTSTER-ROADSTER-BUELL-BLACK-1-4KW-80-10 09-/120833082602?pt=Motorcycles_Parts_Accessories& hash=item1c223684ea&vxp=mtr

1.4 KW vs 1.0 KW on the stock one. $139 vs $375 for the stock one from my local H-D/Buell dealer.

Bolted right in and works great. My old one died a slow death, which made me think my battery was going.

My bike cranks better now than it did when it was new.
Top of pagePrevious messageNext messageBottom of page Link to this message

Argentcorvid
Posted on Tuesday, May 22, 2012 - 04:32 pm:   Edit Post Delete Post View Post/Check IP Print Post    Move Post (Custodian/Admin Only) Ban Poster IP (Custodian/Admin only)

check your cabling, especially where the lugs crimp on. This happened on my sporty, and the strands in the cable were corroded and breaking.
« Previous Next »

Add Your Message Here
Post:
Bold text Italics Underline Create a hyperlink Insert a clipart image

Username: Posting Information:
This is a public posting area. Enter your username and password if you have an account. Otherwise, enter your full name as your username and leave the password blank. Your e-mail address is optional.
Password:
E-mail:
Options: Post as "Anonymous" (Valid reason required. Abusers will be exposed. If unsure, ask.)
Enable HTML code in message
Automatically activate URLs in message
Action:

Topics | Last Day | Tree View | Search | User List | Help/Instructions | Rules | Program Credits Administration